Les portes en section aériennes de la caserne de pompiers sont conçues spécialement pour les casernes de pompiers ou les services d'incendie. Comparés aux portes aériennes régulières, ces portes aériennes utilisent des feux de pompiers ont besoin de plusieurs fonctionnalités uniques, pour répondre à l'exigence dans un emplacement aussi spécial.
1. Couleur à être rouge de feu: c'est pour donner une forte prudence pour les gens et distinguer clairement la caserne des pompiers des autres bâtiments. Les gens peuvent le reconnaître dès le premier aperçu. Ainsi, les panneaux de porte en coupe au-dessus de la maison de pompiers sont tous peints de couleur rouge.
2. Vitesse d'ouverture rapide: Cela signifie que la porte doit s'ouvrir en peu de temps pour permettre une action rapide des combats d'incendie. Les portes en coupe aérienne de la caserne de pompiers peuvent s'ouvrir à une vitesse de 0,3 m / s. La porte pourra donc ouvrir en 10 à 15 secondes, pour gagner du temps pour les pompiers.
3. Toutes les portes peuvent s'ouvrir simultanément: de cette manière, une fois que l'accident de feu se produit, toutes les portes peuvent s'ouvrir en même temps immédiatement. Tous les véhicules de lutte contre les incendies peuvent sortir dans les temps les plus courts.
|
Fast opening and closing
Running speed comparation:
Sectional door: 0.3m/s;
Traditonal roller shutter door: 0.06-0.08m/s;
So, sectional doors are four times the speed of a tradtional roller shutter door. It opens and closed much faster. This bring several big benefits:
-
Improve work efficiency: Workers or forklifts will no need wait long time in front of the door. The material handling speed is higher by at least 3 times than tradional roll up doors;
-
Keep clean and hygiene: The fast running reduces the open time to only seconds in a cycle of passing the door. Thus much less outside air and dust will enter the room;
-
Keep temperature: Heat loss is reduced by large by reducing open time.
|
High frequency working
There is torsion spring balance system around the drive rod. After spring tightened, it can
balance the weight of the door body and reduce the load weight of the motor. So its drive
motor is always in a light-load work state. This is the reason why such doors can work
continually. No need worry its motor will overload and get burnt.
Max work frequency: 800 open-close cycles per day.
|
|
|
Thermal insulated
Door panel is sandwich structure. Total thickness: 40mm. Two surface layer
is 0.326mm galvanized steel plate. Middle is filled with high density fire
ratardant polyurethane foam. Foam Density: 12---14kg/m2.
At the joint area, there is a special cold-bridge design, to avoid direct
heat conduction through surface steel sheet.
Thermal insulation ratio: 4.5W/m. h.
For this reason, such door is widely seen in cold rooms and warehouses.
|
High air-tightness
All-around of the door is covered with EPDM weather seal rubber. Such rubber can resist
cold and chemical. It can keep in good shape after years. This guarantee the high air-tightness of the whole door. It will prevent outside air and dust entering the room, and keep
inside clean and hygiene.
|
|
|
Flexible design to fit all project sites
The door can climb up in different ways to fit specific site situation.
Standard lift: For limited top space, the door will turn to the ceiling directly;
High lift: The door can climb up the wall for some distance and then turn to the ceiling;
Vertical lift: If the ceiling is high enough, the best way is to climb up complete to the top.
|
Pièces facultatives:
Vous pouvez sélectionner des fenêtres effacées pour votre porte sectionnelle . Les gens peuvent voir ce qui se passe d'un autre côté de la porte à travers. Cela peut améliorer la sécurité au lieu de travail. Et vous pouvez décider du nombre de rangées de fenêtres pour chaque porte.
Données techniques:
Applicable location:
|
both interior and exterior
|
Max dimension:
|
10000mm wide*8000mm high
|
Opening Speed:
|
0.3m/s
|
Closing speed:
|
0.3m/s
|
Wind resistance:
|
Beaufort scale 12 (32m/s)
|
Power supply:
|
1-phase 220±10%V,50/60HZ, or 1-phase 380±10%V,50/60HZ
|
Protection level of electric:
|
IP54
|
Frame material:
|
Galvanized steel
|
Thickness of panel:
|
40mm thick or 50mm thick
|
Density of PU foam
|
45kg/m³
|
Sound insulation:
|
24 dB
|
Thermal insulation:
|
0.38 W/m°C
|
Water tightness:
|
30 Pa
|
Power:
|
300W to 1500W
|